Nieco JF64-BG Uživatelský manuál

W A R N I N G :Improper installation, adjustment, alteration, maintenance can cause property damage, injury, or death.Read the installation, operating

10Nieco Corporation - Model JF64-BG6. Multi Product Control (P/N 15161-B) - Used to broil avariety of products that may require different settings (If

11C.2 Lighting Procedures1. Broiler is centered under hood and plugged in2. Gas valve is open when handle is in line (parallel to) the pipe3. Turn ve

12Nieco Corporation - Model JF64-BG1. Allow the broiler to run free of any product for 10 minutes.This will burn the chain clean.2. Turn off the Main

13C.4 Control OperationIMPORTANT:THISBROILERISSHIPPEDWITHFACTORYPRESETSTHATMUSTBECHANGED.Adjust the broil times for safe cook out of your

14Nieco Corporation - Model JF64-BG1. Multi-Product Control (If equipped)How it works: The multi-product control isdesigned to let you broil different

15D. CLEANING ANDDISASSEMBLYTurn broiler off and close the main gas valve. Disconnect the power supply to the broiler before cleaning orservicing. If

16Nieco Corporation - Model JF64-BGInstructions1. Allow the broiler to run free of product for 10 minutes before turning it off. This allows any resi

17Nieco Corporation - Model JF64-BG1. Pull the release pin.2. Lift wire belt feeder bases up and off.3. Wash, rinse, and sanitize in the 3-compartme

18Nieco Corporation - Model JF64-BG1. Pull the release pin.2. Lift push bar and wire belt feeder bases up andoff.3. Wash, rinse, and sanitize in the 3

19Nieco Corporation - Model JF64-BG1. Slide grease pan out.Make sure grease pan is cool before putting inwater or it may warp the pans.2. Take to sink

2TABLE OF CONTENTSA. General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3A.1 Description . . .

20Nieco Corporation - Model JF64-BG1. Slide out from under bun belt.2. Wash, rinse, and sanitize in the 3-compartment sink.Crumb TrayFeed EndToolsInst

21Nieco Corporation - Model JF64-BG1. Lift up and off.2. Take to sink area and spray with degreaser. 3. Wash, rinse, and sanitize in the 3-compartment

22Nieco Corporation - Model JF64-BG1. Lift sizzle plate or catch pan insert up and off.2. Take to sink area and spray with degreaser. 3. Wash, rinse,

23Nieco Corporation - Model JF64-BG1. Lift up and off.2. Take to sink area and spray with degreaser. 3. Wash, rinse, and sanitize in the 3-compartment

24Nieco Corporation - Model JF64-BG1. Lift grease box off.2. Take to sink area and spray with degreaser.3. Wash with a scrub pad, rinse, and sanitize

25Nieco Corporation - Model JF64-BGEXTREMELY HOT! Be careful not to burnyourself. 1. Grasp handle and lift Catalyst off to remove from shroud.2. SOAK

26Nieco Corporation - Model JF64-BGEXTREMELY HOT! Be careful not to burnyourself. 1. Lift Incendalyst™ chimney up and off.2. Take to sink area and spr

27Nieco Corporation - Model JF64-BG1. Lift air upper burner and air box from the top ofthe broiler. It is not necessary to detach them.2. Use a stiff

28Nieco Corporation - Model JF64-BG1. Use a flat head screwdriver or box cutter to clean the slots on the pilot orifices.Pilot OrificesInteriorToolsIn

29Nieco Corporation - Model JF64-BGInner ShieldClean: MonthlyToolsInstructions1. Use scraping tool to reach between belts and remove carbon deposits.

3A. GENERAL INFORMATIONA.1 DescriptionThe Nieco®Model JF63-BG automatic broiler features patented BroilVection™technology, easy cleaning and a simple

30Nieco Corporation - Model JF64-BG1. Scrape each shaft of both belts on the discharge end with the wide end of the shaft cleaning tool. The tool is l

31Nieco Corporation - Model JF64-BGE. TROUBLESHOOTINGAlways verify that the broiler is properly assembled, the hood is on, gas valve open and broiler

32Nieco Corporation - Model JF64-BGF. WIRINGDIAGRAM 15Feb12BModel Rev.This document is the property of Nieco Corporation. Reporduction or release wit

33Nieco Corporation - Model JF64-BGF. WIRINGDIAGRAM

34CAUTIONAll electrical connections must bein accordance with local electricalcodes and any other applicablecodes.CAUTIONDo not operate the broiler at

Nieco Corporation 7950 Cameron Drive Windsor, CA 95492 (707) 284-7100 Office • (707) 284-7430 Faxwww.nieco.com • e-mail: [email protected] in

4A.3 Service/Technical AssistanceIf you experience any problems with the installation or operation of your broiler, contact your localAuthorized Niec

5A.4 Important Safety Information (Continued.)In addition to the warnings and cautions in this manual, use the following guidelines for safe operatio

6Nieco Corporation - Model JF64-BGB. INSTALLATIONB.1 Pre-InstallationUncrate the broiler and inspect for shipping damage. Remove the tape securing t

7B.6 Gas Connection- 3/4” N.P.T. At rated input the gas supply should deliver a minimum pressure of at least 15 mbar (6" water column)at the bro

8Nieco Corporation - Model JF64-BGB.9 Electrical Connection Power requirements are stated on the unit nameplate and must be connected accordingly. Th

9Nieco Corporation - Model JF64-BGC. OPERATION C.1 Controls and Indicators On the front of the broiler:1.Belt Speed Control - Used to set the broil